Wet integrated flue gas cleaning

Ecology and sustainable development. Environmental protection
Proceedings of the 2nd International Scientific Conference «Chemical Technology and Engineering»: June 24–28, 2019, Lviv: Lviv Polytechnic National University, 2018, pp. 352–357

Authors

First and Last Name Academic degree E-mail Affiliation
Igor Volchyn Sc.D. volchyn [at] gmail.com Coal Energy Technology Institute
Kyiv, Ukraine
Vladyslav Rashchepkin Ph.D. slava003 [at] ukr.net Coal Energy Technology Institute
Kyiv, Ukraine
Andrii Yasynetskyi No aoyasyn [at] gmail.com Coal Energy Technology Institute
Kyiv, Ukraine
Wlodzimierz Przybylski No wlodzimierz.przybylski [at] dagas.pl Dagas
Warka, Poland

I and my co-authors (if any) authorize the use of the Paper in accordance with the Creative Commons CC BY license

First publshed on this website: 18.04.2019 - 18:15
Abstract

A wet method for flue gas cleaning from ash and sulfur dioxide based on a wet venturi scrubber has been proposed An increase in the specific consumption of irrigation water in the Venturi tube of 0.7 kg/m3 and higher will allow reaching an output dust concentration below 20 mg/m3, while reducing the energy consumption of flue gas for droplet evaporation and fresh water consumption. The use of ammonia in wet desulfurization technology will allow the use of an existing wet scrubber while observing the SO2 limit concentration of 200 mg/m3.

References

[1] “Direcеive 2010/75/EU of the European Parliament and of the Council of 24 November 2010 on industrial emissions (integrated pollution prevention and control)”, OJ L 334, 17.12.2010.

[2] “On the National Emission Reduction Plan for the Large Combustion Plants”. Decision of the Cabinet of Ministers of Ukraine. No. 796-p. dated 8 Nov., 2017. — Available: http://zakon3.rada.gov.ua/laws/show/796-2017-p. (Ukr). [Accepted Apr. 11, 2019]

[3] “Best Available Techniques (BAT) Reference Document for Large Combustion Plants”. Joint Research Centre (JRC), Spain. 2017. 986 p.Available:– http://eippcb.jrc.ec.europa.eu/reference/BREF/LCP/JRC107769_LCP_bref2017.... [Accepted Apr. 11, 2019]

[4] Volchyn I.A. “Perspektyvy vprovadzhennia chystykh vuhilnykh tekhnolohij v enerhetyku Ukrainy” [“Prospects for the introduction of clean coal technologies in the energy sector of Ukraine”] / I.A. Volchyn, N.I. Dunayevska, L.S. Haponych, M.V. Cherniavskyi, O.I. Topal, Ya.I. Zasiadko. – K.: GNOZIS. – 2013. – 310 s. (Ukr).

[5] Anichkov S.N., Giniyatullin R.I., Zykov A.M. “Povyshenije effektivnosti ulavlivanija letuchej zoly v apparatakh mokrogo zoloulavlivanija” [“Increase of the efficiency of fly ash capture in devices of wet ash collecting”]. Elektricheskiye stantsii [Electrical plants]. 2009. No. 8. pp. 59–62.(Rus.)

[6] Volchyn I.A., Raschepkin V.A. “Matematicheskoje modelirovanije protsessov koaguljatsii chastits letuchej zoly s kapliami zhydkosti v trubakh Venturi skrubberov TES”. [“Mathematical modeling of the processes of coagulation of fly ash particles with droplets of liquid in Venturi tubes of wet scrubbers of thermal power plants”]. Energotekhnologii i resursosberezhenie [Energy Technologies and Resource Saving]. 2012. No. 2. pp. 44–53. (Rus.)

[7] Volchyn I., Rashchepkin V., Iasynetskyi A. “Flue gas dedusting in Venturi scrubbers at the thermal power plants”. Environmental Engineering and Management Journal, 2018, V. 17, No 11. – P. 2515-2525.

[8]. Costa M.A., Ribeiro A.P., Tognetti E.R., Aguiar M.L., Goncalves J.A.S., Coury J.R. “Performance of a Venturi Scrubber in the Removal of Fine Powder from a Confined Gas Stream”. Materials Research. 2005. 8 (2). pp. 177–179.

[9] Ravi G., Gupta S.K., Viswanathan S., Ray M.B. Optimization of Venturi Scrubbers Using Genetic Algorithm. Ind. Eng. Chem. Res. 2002. 41. pp. 2988–3002.

[10] Evans A.P., Miller C., Pouliot S. “Operational Experience of Commercial, Full Scale Ammonia-Based Wet FGD for Over a Decade”, in Proc. Coal-Gen 2009, Charlotte, North Carolina, USA, August 20, 2009. 19 p.

[11] Volchyn I.A., Raschepkin V.A. “Osobennosti ochistki dymovykh gazov v mokrykh skrubberakh s truboi Venturi v usloviyakh povyshennogo orosheniya” [“Specific Issues of Flue Gas Cleaning in Wet Venturi Scrubbers at Excess Spraying”]. Energotekhnologii i resursosberezhenie [Energy Technologies and Resource Saving]. 2018. No. 3. pp. 41–50. (Rus.)

Official paper